Product ID:SG-741;SILICONE COMPOUND
MSDS Date:03/13/1989
FSC:6850
NIIN:00-927-9461
MSDS Number: BHCVJ

Emergency Phone: 203-531-5500

Info Phone: 203-531-5500

Cage: 33530

Telephone: 203-531-5500

Cage: 33530

POLYMETHYLPHENYLSILOXANE

ZINC OXIDE

CAS: 1314-13-2

RTECS: ZH4810000

OSHA PEL 15MG/M3 TDUST/5 FUME

ACGIH TLV: 10MG/M3 TDUST; 9293

Routes of Entry: Inhalation:UNKNOWN Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATION OF EYES,SKIN;CNS
EFFECTS LIKE HEADACHE,DIZZINESS,NAUSEA,VOMITING;REDNESS OR BURNS OF
EYES/SKIN POSSIBLE.CHRONIC:NO DATA AVAILABLE.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:SEE HEALTH HAZARDS DATA.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.

First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
FOR 15 MINUTES HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION.
SKIN:REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER. IF
IRRITATION PERSISTS, GET MEDICAL ADVICE. INGESTION:DO NOT INDUCE
VOMITING. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET IMMEDIATE
MEDICAL ATTENTION.

Flash Point Method:TOC
Flash Point:<500F,<260C
Extinguishing Media:NOT FLAMMABLE;USE CARBON DIOXIDE, FOAM, DRY
CHEMICAL, OR WATER FOG IF APPLICABLE.
Fire Fighting Procedures:IIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF TOXIC FUME OF ZINC.

Spill Release Procedures:USE PROPER PERSONAL PROTECTION;CONTAIN FREE
MATERIAL IF POSSIBLE OR WIPE UP AND RECOVER FOR PROPER DISPOSAL IN
AN APPROVED CONTAINER.
Neutralizing Agent:NOT APPLICABLE.

Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. PROTECT
CONTAINERS FROM PHYSICAL DAMAGE.
Other Precautions:DO NOT TAKE INTERNALLY. AVOID CONTACT WITH EYES. USE
WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING.

Respiratory Protection:NORMALLY NOT REQUIRED;USE NIOSH/MSHA APPROVED
RESPIRATOR AS REQUIRED IF ABOVE PEL/TLV OR SCBA IN AN ENCLOSED
AREA.
Ventilation:NORMAL ROOM VENTILATION OR LOCAL/GENERAL TO MAINTAIN
PEL/TLV.
Protective Gloves:IMPERVIOUS.
Eye Protection:SAFETY GOGGLES.
Other Protective Equipment:EYE WASH STATION,WORK CLOTHING AND APRON AS
REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS.

HCC:N1
Boiling Pt:B.P. Text:>600F,>316C
Vapor Pres:<1.0MM HG
Spec Gravity:2.75
Solubility in Water:NEGLIGIBLE
Appearance and Odor:OPAQUE GREASE,ESSENTIALLY ODORLESS
Percent Volatiles by Volume:NONE

Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY THE MGF
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
SILICONE OXIDE& ZINC METAL FUMES AND OTHER UNIDENTIFIED COMPONENTS.

Waste Disposal Methods:CONSULT LOCAL AUTHORITIES.DISPOSAL MUST BE MADE
IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.